Section 2 - Composition, Information on Ingredients

CAS#	Chemical Name	Percent	EINECS/ELINCS
590-35-2	2,2-Dimethylpentane	>99	209-680-5

Section 3 - Hazards Identification

Appearance: colorless clear liquid. Flash Point: -9 deg C.
Danger! Extremely flammable liquid and vapor. Vapor may cause flash fire. Causes eye, skin, and respiratory tract irritation. Breathing vapors may cause drowsiness and dizziness. Aspiration hazard if swallowed. Can enter lungs and cause damage.
Target Organs: Central nervous system, lungs, eyes, skin.


Potential Health Effects
Eye: Causes eye irritation.
Skin: Causes skin irritation. May be harmful if absorbed through the skin.
Ingestion: Aspiration hazard. May cause irritation of the digestive tract. May cause central nervous system depression, characterized by excitement, followed by headache, dizziness, drowsiness, and nausea. Advanced stages may cause collapse, unconsciousness, coma and possible death due to respiratory failure. Aspiration of material into the lungs may cause chemical pneumonitis, which may be fatal. May be harmful if swallowed.
Inhalation: Causes respiratory tract irritation. May cause narcotic effects in high concentration. May be harmful if inhaled.
Chronic: No information found.

Section 4 - First Aid Measures

Eyes: Flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid.
Skin: Get medical aid. Flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Ingestion: Potential for aspiration if swallowed. Get medical aid immediately. Do not induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an unconscious person. If vomiting occurs naturally, have victim lean forward.
Inhalation: Remove from exposure and move to fresh air immediately. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical aid.
Notes to Physician: Treat symptomatically and supportively.

Section 5 - Fire Fighting Measures

General Information: As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. Vapors can travel to a source of ignition and flash back. Extremely flammable liquid and vapor. Vapor may cause flash fire.
Extinguishing Media: Use foam, dry chemical, or carbon dioxide.
Flash Point: -9 deg C ( 15.80 deg F)
Autoignition Temperature: Not available.
Explosion Limits, Lower:1 Vol%
Upper: 8.3 Vol%
NFPA Rating: (estimated) Health: ; Flammability: 3; Instability:

Section 6 - Accidental Release Measures

General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks: Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container. Remove all sources of ignition. Use a spark-proof tool. Provide ventilation.

Section 7 - Handling and Storage

Handling: Wash thoroughly after handling. Remove contaminated clothing and wash before reuse. Ground and bond containers when transferring material. Use spark-proof tools and explosion proof equipment. Avoid contact with eyes, skin, and clothing. Empty containers retain product residue, (liquid and/or vapor), and can be dangerous. Use only with adequate ventilation. Keep away from heat, sparks and flame. Avoid breathing vapor or mist.
Storage: Keep away from sources of ignition. Store in a cool, dry place. Store in a tightly closed container. Flammables-area.

Section 8 - Exposure Controls, Personal Protection

Engineering Controls: Use process enclosure, local exhaust ventilation, or other engineering controls to control airborne levels below recommended exposure limits. Use explosion-proof ventilation equipment. Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower.
Exposure Limits

Chemical Name	ACGIH	NIOSH	OSHA - Final PELs
2,2-Dimethylpentane	400 ppm TWA (listed under Heptane, all isomers); 500 ppm STEL (listed under Heptane, all isomers)	85 ppm TWA; 350 mg/m3 TWA (listed under Heptane (n-)).750 ppm IDLH (listed under Heptane (n-)).	500 ppm TWA; 2000 mg/m3 TWA (listed under Heptane (n-)).

OSHA Vacated PELs: 2,2-Dimethylpentane: No OSHA Vacated PELs are listed for this chemical.
Personal Protective Equipment
Eyes: Wear chemical splash goggles.
Skin: Wear appropriate protective gloves to prevent skin exposure.
Clothing: Wear appropriate protective clothing to prevent skin exposure.
Respirators: Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.

Section 9 - Physical and Chemical Properties

Physical State: Clear liquid
Appearance: colorless
Odor: Not available.
pH: Not available.
Vapor Pressure: Not available.
Vapor Density: Not available.
Evaporation Rate:Not available.
Viscosity: Not available.
Boiling Point: 79 deg C
Freezing/Melting Point:Not available.
Decomposition Temperature:Not available.
Solubility: Not available.
Specific Gravity/Density:0.6739
Molecular Formula:C7H16
Molecular Weight:100.2

Section 10 - Stability and Reactivity

Chemical Stability: Not available.
Conditions to Avoid: Ignition sources.
Incompatibilities with Other Materials: Strong oxidizing agents.
Hazardous Decomposition Products: Carbon monoxide, carbon dioxide.
Hazardous Polymerization: Has not been reported

Section 11 - Toxicological Information

RTECS#:      
CAS# 590-35-2 unlisted.
LD50/LC50:
Not available.

Carcinogenicity:
CAS# 590-35-2: Not listed by ACGIH, IARC, NTP, or CA Prop 65.

Epidemiology: No data available.
Teratogenicity: No data available.
Reproductive Effects: No data available.
Mutagenicity: No data available.
Neurotoxicity: No data available.
Other Studies:

Section 12 - Ecological Information

No information available.

Section 13 - Disposal Considerations

Chemical waste generators must determine whether a discarded chemical is classified as a hazardous waste. US EPA guidelines for the classification determination are listed in 40 CFR Parts 261.3. Additionally, waste generators must consult state and local hazardous waste regulations to ensure complete and accurate classification.
RCRA P-Series: None listed.
RCRA U-Series: None listed.

Section 14 - Transport Information

	US DOT	Canada TDG
Shipping Name:	DOT regulated - small quantity provisions apply (see 49CFR173.4)	Heptanes
Hazard Class:		3
UN Number:		UN1206
Packing Group:		II

Section 15 - Regulatory Information

US FEDERAL

TSCA
     CAS# 590-35-2 is listed on the TSCA inventory.
Health & Safety Reporting List
     None of the chemicals are on the Health & Safety Reporting List.
Chemical Test Rules
     None of the chemicals in this product are under a Chemical Test Rule.
Section 12b
     None of the chemicals are listed under TSCA Section 12b.
TSCA Significant New Use Rule
     None of the chemicals in this material have a SNUR under TSCA.
CERCLA Hazardous Substances and corresponding RQs
     None of the chemicals in this material have an RQ.
SARA Section 302 Extremely Hazardous Substances
     None of the chemicals in this product have a TPQ.
Section 313      No chemicals are reportable under Section 313.
Clean Air Act:
     This material does not contain any hazardous air pollutants.
     This material does not contain any Class 1 Ozone depletors.
     This material does not contain any Class 2 Ozone depletors.
Clean Water Act:
     None of the chemicals in this product are listed as Hazardous Substances under the CWA.
     None of the chemicals in this product are listed as Priority Pollutants under the CWA.
     None of the chemicals in this product are listed as Toxic Pollutants under the CWA.
OSHA:
     None of the chemicals in this product are considered highly hazardous by OSHA.
STATE
     CAS# 590-35-2 can be found on the following state right to know lists: California, (listed as Heptane (n-)), New Jersey, (listed as Heptane (n-)), Pennsylvania, (listed as Heptane (n-)), Minnesota, (listed as Heptane (n-)), Massachusetts, (listed as Heptane (n-)).

California Prop 65

California No Significant Risk Level: None of the chemicals in this product are listed.

European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols:
     XN F N
Risk Phrases:
     R 11 Highly flammable.
     R 38 Irritating to skin.
     R 50/53 Very toxic to aquatic organisms, may cause long-term
     adverse effects in the aquatic environment.
     R 65 Harmful: may cause lung damage if swallowed.
     R 67 Vapours may cause drowsiness and dizziness.

Safety Phrases:
     S 16 Keep away from sources of ignition - No smoking.
     S 29 Do not empty into drains.
     S 33 Take precautionary measures against static discharges.
     S 9 Keep container in a well-ventilated place.
     S 60 This material and its container must be disposed of as hazardou
     s waste.
     S 61 Avoid release to the environment. Refer to special instructions
     /safety data sheets.
     S 62 If swallowed, do not induce vomiting: seek medical advice immed
     iately and show this container or label.

WGK (Water Danger/Protection)
     CAS# 590-35-2: No information available.
Canada - DSL/NDSL
     CAS# 590-35-2 is listed on Canada's NDSL List.
Canada - WHMIS
     WHMIS: Not available.
This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all of the information required by those regulations.
Canadian Ingredient Disclosure List
     CAS# 590-35-2 (listed as Heptane (n-)) is listed on the Canadian Ingredient Disclosure List.

Section 16 - Additional Information

MSDS Creation Date: 1/16/2002
Revision #2 Date: 9/26/2007

The information above is believed to be accurate and represents the best information currently available to us. However, we make no warranty of merchantability or any other warranty, express or implied, with respect to such information, and we assume no liability resulting from its use. Users should make their own investigations to determine the suitability of the information for their particular purposes. In no event shall Fisher be liable for any claims, losses, or damages of any third party or for lost profits or any special, indirect, incidental, consequential or exemplary damages, howsoever arising, even if Fisher has been advised of the possibility of such damages.