Section 2 - Composition, Information on Ingredients

CAS#	Chemical Name	Percent	EINECS/ELINCS
111-19-3	Sebacoyl chloride	92+	203-843-4

Section 3 - Hazards Identification

Appearance: light yellow clear liquid.
Danger! Causes burns by all exposure routes. Contact with water liberates toxic gas. Harmful if swallowed, inhaled, or absorbed through the skin.
Target Organs: Respiratory system, gastrointestinal system, eyes, skin.


Potential Health Effects
Eye: Causes eye burns. Lachrymator (substance which increases the flow of tears).
Skin: Harmful if absorbed through the skin. Causes skin burns.
Ingestion: Harmful if swallowed. Causes gastrointestinal tract burns.
Inhalation: Harmful if inhaled. Causes chemical burns to the respiratory tract.
Chronic: Prolonged or repeated skin contact may cause dermatitis. Repeated exposure may cause erosion of teeth.

Section 4 - First Aid Measures

Eyes: Immediately flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid imme diately.
Skin: Get medical aid immediately. Immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Ingestion: Do not induce vomiting. Get medical aid immediately. Call a poison control center.
Inhalation: Get medical aid immediately. Remove from exposure and move to fresh air immediately. If breathing is difficult, give oxygen. Do not use mouth-to-mouth resuscitation if victim ingested or inhaled the substance; induce artificial respiration with the aid of a pocket mask equipped with a one-way valve or other proper respiratory medical device.
Notes to Physician: Treat symptomatically and supportively.

Section 5 - Fire Fighting Measures

General Information: As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. Water reactive. Material will react with water and may release a flammable and/or toxic gas.
Extinguishing Media: Use foam, dry chemical, or carbon dioxide. DO NOT USE WATER!
Flash Point: > 112 deg C (> 233.60 deg F)
Autoignition Temperature: Not applicable.
Explosion Limits, Lower:Not available.
Upper: Not available.
NFPA Rating: (estimated) Health: 3; Flammability: 1; Instability: 2; Special Hazard: -W-

Section 6 - Accidental Release Measures

General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks: Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container. Wear a self contained breathing apparatus and appropriate personal protection. (See Exposure Controls, Personal Protection section). Provide ventilation. Do not expose spill to water. Do not get water inside containers. Do not let this chemical enter the environment.

Section 7 - Handling and Storage

Handling: Do not allow water to get into the container because of violent reaction. Do not get in eyes, on skin, or on clothing. Do not ingest or inhale. Do not allow contact with water. Use only in a chemical fume hood.
Storage: Store in a cool, dry place. Store in a tightly closed container. Corrosives area. Store protected from moisture. Store under nitrogen.

Section 8 - Exposure Controls, Personal Protection

Engineering Controls: Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use only under a chemical fume hood.
Exposure Limits

Chemical Name	ACGIH	NIOSH	OSHA - Final PELs
Sebacoyl chloride	none listed	none listed	none listed

OSHA Vacated PELs: Sebacoyl chloride: No OSHA Vacated PELs are listed for this chemical.
Personal Protective Equipment
Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin: Wear appropriate protective gloves to prevent skin exposure.
Clothing: Wear appropriate protective clothing to prevent skin exposure.
Respirators: Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.

Section 9 - Physical and Chemical Properties

Physical State: Clear liquid
Appearance: light yellow
Odor: irritating odor
pH: Not available.
Vapor Pressure: 75 mm Hg @ 220 deg C
Vapor Density: 8.25 (air=1)
Evaporation Rate:Not available.
Viscosity: Not available.
Boiling Point: 220 deg C @ 75 mm Hg
Freezing/Melting Point:-2.5 deg C
Decomposition Temperature:Not available.
Solubility: May decompose.
Specific Gravity/Density:1.121
Molecular Formula:C10H16Cl2O2
Molecular Weight:239.14

Section 10 - Stability and Reactivity

Chemical Stability: Moisture sensitive. Material hydrolyzes in contact with moisture/water releasing toxic and corrosive fumes of hydrogen chloride and aqueous hydrochloric acid.
Conditions to Avoid: Incompatible materials, exposure to moist air or water.
Incompatibilities with Other Materials: Alcohols, oxidizing agents, strong acids, bases.
Hazardous Decomposition Products: Hydrogen chloride, phosgene, carbon monoxide, carbon dioxide.
Hazardous Polymerization: Will not occur.

Section 11 - Toxicological Information

RTECS#:      
CAS# 111-19-3: HD8454250
LD50/LC50:
CAS# 111-19-3:
     Dermal, guinea pig: LD50 = 50 uL/kg;
     Draize test, rabbit, eye: 45 uL Severe;
     Oral, mouse: LD50 = >1600 mg/kg;
     Oral, rat: LD50 = 400 mg/kg;
.

Carcinogenicity:
CAS# 111-19-3: Not listed by ACGIH, IARC, NTP, or CA Prop 65.

Epidemiology: No information found
Teratogenicity: No information found
Reproductive Effects: No information found
Mutagenicity: No information found
Neurotoxicity: No information found
Other Studies:

Section 12 - Ecological Information

Ecotoxicity: No data available. No information available.
Environmental: No information available.
Physical: No information available.
Other: Do not empty into drains.

Section 13 - Disposal Considerations

Chemical waste generators must determine whether a discarded chemical is classified as a hazardous waste. US EPA guidelines for the classification determination are listed in 40 CFR Parts 261.3. Additionally, waste generators must consult state and local hazardous waste regulations to ensure complete and accurate classification.
RCRA P-Series: None listed.
RCRA U-Series: None listed.

Section 14 - Transport Information

	US DOT	Canada TDG
Shipping Name:	WATER-REACTIVE LIQUID, CORROSIVE, N.O.S.	WATER-REACTIVE LIQUID, CORROSIVE, N.O.S. (SEBACOYL CHLORIDE)
Hazard Class:	4.3	4.3
UN Number:	UN3129	UN3129
Packing Group:	II	II

Section 15 - Regulatory Information

US FEDERAL

TSCA
     CAS# 111-19-3 is listed on the TSCA inventory.
Health & Safety Reporting List
     None of the chemicals are on the Health & Safety Reporting List.
Chemical Test Rules
     None of the chemicals in this product are under a Chemical Test Rule.
Section 12b
     None of the chemicals are listed under TSCA Section 12b.
TSCA Significant New Use Rule
     None of the chemicals in this material have a SNUR under TSCA.
CERCLA Hazardous Substances and corresponding RQs
     None of the chemicals in this material have an RQ.
SARA Section 302 Extremely Hazardous Substances
     None of the chemicals in this product have a TPQ.
SARA Codes
     CAS # 111-19-3: immediate, reactive.
Section 313      No chemicals are reportable under Section 313.
Clean Air Act:
     This material does not contain any hazardous air pollutants.
     This material does not contain any Class 1 Ozone depletors.
     This material does not contain any Class 2 Ozone depletors.
Clean Water Act:
     None of the chemicals in this product are listed as Hazardous Substances under the CWA.
     None of the chemicals in this product are listed as Priority Pollutants under the CWA.
     None of the chemicals in this product are listed as Toxic Pollutants under the CWA.
OSHA:
     None of the chemicals in this product are considered highly hazardous by OSHA.
STATE
     CAS# 111-19-3 is not present on state lists from CA, PA, MN, MA, FL, or NJ.

California Prop 65

California No Significant Risk Level: None of the chemicals in this product are listed.

European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols:
     C
Risk Phrases:
     R 20/21/22 Harmful by inhalation, in contact with skin and if
     swallowed.
     R 29 Contact with water liberates toxic gas.
     R 34 Causes burns.

Safety Phrases:
     S 26 In case of contact with eyes, rinse immediately with plenty of
     water and seek medical advice.
     S 36/37/39 Wear suitable protective clothing, gloves and eye/face pr
     otection.
     S 45 In case of accident or if you feel unwell, seek medical advice
     immediately (show the label where possible).
     S 8 Keep container dry.

WGK (Water Danger/Protection)
     CAS# 111-19-3: No information available.
Canada - DSL/NDSL
     CAS# 111-19-3 is listed on Canada's DSL List.
Canada - WHMIS
     This product has a WHMIS classification of E, D1B.
This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all of the information required by those regulations.
Canadian Ingredient Disclosure List

Section 16 - Additional Information

MSDS Creation Date: 9/02/1997
Revision #8 Date: 4/22/2008

The information above is believed to be accurate and represents the best information currently available to us. However, we make no warranty of merchantability or any other warranty, express or implied, with respect to such information, and we assume no liability resulting from its use. Users should make their own investigations to determine the suitability of the information for their particular purposes. In no event shall Fisher be liable for any claims, losses, or damages of any third party or for lost profits or any special, indirect, incidental, consequential or exemplary damages, howsoever arising, even if Fisher has been advised of the possibility of such damages.